Copper-nickel heat exchangers and cast iron manifolds resist corrosion and electrolysis.Single-piece cast iron heat exchanger, expansion tank and exhaust manifold.Experienced engineering and high-quality components reduce belts and hoses to a minimum.Engine provides high torque at low RPM.In addition to easy access, this permits the generator set to be installed near a wall or bulkhead, saving valuable space. Common service points, including filters, fills and drains are on a single side.Should you have any further issues, please contact a specialist or Northern Lights support. These are just some of the most common technical issues with marine generators. Make sure all connections are tight before re-applying pressure. Escaping fluid under pressure can penetrate skin and cause serious injury. Relieve pressure before disconnecting pressurized lines.Battery electrolyte can burn through skin or closing, beware.Frozen batteries may explode if charged.Contact with fans, belts, pulley and drives in operation will cause serious injury.Disconnect battery ground cable before working on generator.Do not wear dangling clothing or jewelry while working on machine.Diesel is highly flammable, don’t smoke or be near possible source of sparks / flames.Do not start engine by shorting across start terminal.= *Warning and Safety Precautions Before Working On Marine Generator Partially plugged oil filter? (replace Northern Lights oil filter).Clogged filter and strainer or worn bearings and oil pump (repair or replace necessary part for your model).Low oil level (fill crankcase to proper level).Water pump impeller worn / broken (check water pump impeller, and replace if necessary).Defective temperature gauge (check water temperature with thermometer, and replace gauge if necessary).Defective thermostat (check, and replace thermostat if necessary).Keel cooling tubes have been painted (remove paint if possible, otherwise replace keel cooling tube).Low coolant, or defective cooling system (refill coolant, check hoses for leaks/loose connections, slipping fan belt).Fuel injection but no ignition (glow plug malfunction, incorrect injection timing, low compression pressure in cylinder).Dirty injection nozzles (check injectors, replace if necessary).Clogged primary or secondary Northern lights fuel filter element (Clean or replace primary filter element, replace secondary filter element).Water, dirt or air in fuel system (drain, flush, fill, bleed system).Improper fuel (consult fuel supplier verify proper fuel type).Crankcase oil too thick (use proper oil, proper viscosity).Low battery output (check electrolyte levels and connection, tighten all connections).Low battery output (check electrolyte and specific gravity levels)Įngine Difficult To Start or Won’t Start?.Loose or corroded connections (clean and tighten loose battery and harness plug connection).Check DC circuit breaker (reset if necessary).Loose or dysfunctional alternator belt (tighten or replace belt).Sulfated / worn out batteries (check specific gravity of batteries using a hydrometer, check electrolyte levels).Loose or corroded connections (clean and tighten connections to battery).If not familiar / comfortable with working on machinery such as a generator, consider contacting an expert. IMPORTANT: Make sure to review warnings and safety precautions* below before working on marine generator. ![]() This advice is meant to help, but not to replace advice from a specialist or Northern Lights support. Should you have any more questions, or concern about any of these issues, please contact Northern Lights support directly. In order to help address these common issues, we’ve put together this Northern Lights Generator Troubleshooting Guide.īelow we’ve compiled the main issues that you may face with a Northern Lights generator, and provide you with solutions. Northern Lights marine generators generally do not have many issues, as long as proper maintenance and changing of filters is kept up with… however, if you are experiencing an issue with your generator, the problems are generally pretty easy to figure out / fix. Watermaker Parts, Accessories & Consumables ›.Village Marine Little Wonder (Parker) ›.Renogy Solar Panels, Solar Power Kits & Equipment ›.Go Power Solar Panels, Inverters & Kits ›.Marine Fuel Filter / Water Separators ›.Mastervolt Combis Inverter / Chargers ›.Prespliced Double Braid Nylon Dock Line ›.Installation Kits, Blowers, and Ducting ›.Easy Start, Smart Start, and Electrical Components ›.Displays, Covers, Cables, and Retrofit Kits ›.
0 Comments
Leave a Reply. |